Bacon Wrapped Sausage Fatty: Ham n’ Cheddar
Smoking-Meat.com is supported by its readers. We may earn an affiliate commission at no extra cost to you if you buy through a link on this page.
Read this article without ads
Words cannot describe how good and how unhealthy this bacon wrapped sausage fatty is. Eat moderately to stay healthy, but you do need to try this.
I stuffed this one full of cheese and ham, and boy was it cheesy and delicious with every bite!
- Prep Time: 45 minutes
- Cook Time: 3 hours
- Smoker Temp: 225-240°F
- Meat Finish Temp: 160°F
- Recommended Wood: Oak or Pecan
- 2 lbs ground breakfast sausage (Jimmy Deans, JC Potter, etc.)
- 1 lb original or thin sliced bacon (16 slices approx.)
- ½ lb ham, diced into quarter inch pieces
- 1.5 cups sharp cheddar, grated
- Jeff's original rub
- Jeff's original barbecue sauce
- Foil and/or wax paper
This is one of those things that looks difficult but it's really not, so don't be discouraged before you even begin.
You can do this!
Start by laying about 8 pieces of bacon horizontally on a piece of foil that is 3-4 inches wider and longer than the expected bacon weave. I normally use a piece that is about 18″ x 24″.
To make a weave, fold back every other piece on the right side about 1 inch, starting with the second one.
Lay a strip of bacon vertically all the way to the right.
Then the pieces that got folded back, go back to where they were.
Next, we will once again fold back every other strip of bacon on the right side, only this time we'll begin with the first one.
Lay another strip of bacon vertically on the right side butted up against the first one.
The pieces that got folded back, go back to where they were.
You continue this process until you have a bacon weave that is 8 slices by 8 slices or one that equals 12 inches by 12 inches approximately.
This is how it looks when you are finished:
Apply a healthy portion of Jeff's original rub to the top side of the bacon to finish off the weave.
Once the weave is complete, slide the foil or wax paper that the weave is sitting on, onto a baking sheet, and place it in the fridge while you roll out the sausage.
The cold fridge will help to firm up the bacon and make it easier to work with.
I used JC Potter Hot, but you can use another flavor if you like.
Remove the wrapper from the sausage chubs.
Place the sausage into a gallon sized zip top bag.
Flatten the sausage with your hands.
Make sure the thickness is as uniform as possible.
If you get air bubbles, you can snip the corners of the bag or leave it slightly unzipped at the top to help expel the trapped air.
Now it's time to remove the top layer of the bag.
Snip the corners of the zipper, and then use kitchen shears or scissors to cut along the seam on both sides of the bag.
Peel off the top layer of the bag.
Cut along the bottom seam to to completely remove the top layer of plastic.
Add a good, healthy sprinkling of Jeff's original rub to the top side of the sausage.
Turn the sausage 90° so the long edge is facing you.
Place about ½ lb of diced ham onto the top of the sausage. Leave about 2 inches at the bottom and top and about 1 inch on the sides.
Season the ham with Jeff's original rub.
Place about 1.5 cups of shredded sharp cheddar cheese to the top of the ham.
Roll the sausage into a chub using the plastic bag like a sushi rolling mat.
Tip: use your hands to push the ham and cheese back into the sausage roll if it tries to fall out of the front or sides while you are rolling it.
Carefully move the rolled sausage chub onto the top of the bacon weave.
The sausage roll will do best if you make sure it ends up about 2-3 inches from the edge of the bacon weave.
Press in on the ends of the sausage to adjust the width of the roll. It is best if the bacon weave is slightly wider than the sausage roll.
I also like to pull some sausage from the ends of the roll down to seal the opening to keep the cheese and ham from falling out.
Alternatively, you could have some extra sausage ready for this purpose. Pinch it into place to seal off the ends.
Using the foil like a sushi rolling mat, wrap the shorter edge of bacon at the top around the sausage roll and then continue to roll the sausage toward you as the bacon wraps around it.
When the bacon is completely wrapped around the sausage roll, roll the bacon wrapped sausage roll in the opposite direction away from you, allowing the foil to wrap around it.
This will allow us to shape the roll and to place it in the fridge to firm up.
I recommend allowing it to firm up for at least an hour before smoking it, but overnight is preferable.
The foil wrapped fatty is placed on a Weber grill pan or baking sheet and placed in the fridge ready for the smoker.
When you are ready to cook, remove it from the fridge and remove the foil.
Sprinkle Jeff's original rub onto the outside of the bacon wrapped sausage chub.
Setup your smoker for cooking at 225°F (107°C) using indirect heat. If your smoker uses a water pan, fill it up.
When the smoker is ready, place the bacon wrapped sausage roll directly onto the grate or you can leave it on a pan with a rack or the weber grill pan to make it easier to handle.
When the bacon wrapped sausage roll reaches 160°F (71°C) in the thickest part (about three hours), brush on a thin coat of Jeff’s original barbecue sauce and let it continue to cook in the smoker for about 10 minutes to allow the sauce to glaze.
Remove the meat from the smoker and set it on the counter to rest for 5-10 minutes.
With a very sharp knife, slice the roll into pieces that are about ½ to ¾ inch thick and serve immediately.
Smoked Bacon Wrapped Sausage Fatty: Ham n' Cheddar
Ingredients
- 2 lbs ground breakfast sausage (Jimmy Deans, JC Potter, etc.)
- 1 lb original or thin sliced bacon (16 slices approx.)
- ½ lb ham (diced into quarter inch pieces)
- 1.5 cups sharp cheddar (grated)
- Jeff's original rub
- Jeff's original barbecue sauce
- Foil and/or wax paper
Instructions
- Make a bacon weave with 8 horizontal strips and 8 vertical strips on a large piece of foil. It should end up being about 12 inches by 12 inches. Season the top of the bacon weave with Jeff's original rub then place the bacon weave in the fridge to firm up.
- Place 2 lbs of ground sausage into a zip top bag. Flatten the sausage inside the bag until is of equal thickness. Use scissors to cut along the seams and remove the top layer of the plastic bag.
- Season the top of the sausage with Jeff's original rub.
- Lay the flattened sausage onto the bacon weave with the top edge about 3 to 4 inches from the top edge of the bacon weave. Place ½ lb of diced ham and 1.5 cups of sharp cheddar cheese onto the flattened sausage. Leave about 2 inches at the top and bottom and 1 inch on the sides.
- Season the ham and cheese with Jeff's original rub.
- Using the plastic like a sushi mat, roll the sausage and stuffing into a roll and onto the bacon weave. Seal the ends of the sausage roll with more sausage to keep the cheese and ham from falling out during the cooking process.
- Using the foil like a sushi mat, wrap the bacon weave around the sausage roll. Wrap the roll tightly in foil. Place the wrapped sausage roll in the fridge to firm up for at least an hour or overnight.
- Just before cooking, season the outside of the bacon with Jeff's original rub.
- Setup your smoker for cooking at 225°F (107°C) using indirect heat. If your smoker uses a water pan, fill it up.
- Place the bacon wrapped sausage roll directly onto the smoker grate or use a pan with a rack or the Weber grill pan to make it easy.
- Cook the sausage roll for about 3 hours or until the inside of the meat reaches 160°F (71°C).
- Glaze the outside with Jeff's original barbecue sauce if desired and let it continue cooking for about 10 minutes to glaze the sauce.
- Remove from the smoker and let it rest for 10 minutes.
- Slice and serve.
I made this today. It was much easier than I had anticipated and turned out excellent. It looked like a work of art. I’m kind of proud of it. Thanks Jeff👍👍👍
Try it with Italian sausage & fill it with pesto, shrooms, chopped garlic and fetta cheese!
simply amazing!!
I love fatty’s but I always pinch the end off and usually wrap an extra slice of bacon around the ends to keep them from blowing out. On one of my first ones I didn’t and it literally oozed all the cheese out.
And also, put your thermometer probe in when it is cold, it you poke that bad boy when its hot you can get an eruption of molten cheese too.
Try Italian some time with Italian sausage, a little pizza sauce, pepperoni, basil and mozzarella. I lay down a layer of pepperoni on top of the bacon before I roll it up and then more on the inside. I’ve put more veggies on the inside like mushrooms onions and peppers but you need to cook them down a bit before putting them in to get some of the moisture out.
Dang, now I’m going to have to make one this weekend!
I like to roll the Fatty separately and then lay it on top of the weave diagonally so that it goes from corner to corner. The extra length of the diagonal weave makes sure the ends of the Fatty are covered, helping to prevent leaks. I make sure to put the seam of the rolled Fatty down against the bacon. That way, when it is rolled and put on the grill pan, the seam of the Fatty is up and tightly covered by the bacon weave, again, helping to prevent leaks. I fold the corners of the weave that are at the ends of the Fatty over the ends, and then roll the rest up. Sorta like rolling a burrito.
It also make the weave look a little prettier.
I tried your other recipe, spinach and sausage. I used Italian hot sausage instead of breakfast sausage. I used the fresh spinach and an assortment of cheeses, pepper jack, queso, extra sharp cheddar. Everyone loved it.
Are your rub and sauce recipes in your book.
Can this be reheated? If so how would you recommend.
You could probably reheat the whole thing on a pan in a 275 – 325 degree oven until it was hot all the way through but I usually slice it cold and pan fry individual slices to heat it up. Works well for me.
Great job on the illustrations Jeff! This is a great recipe.